DeWalt DCMWSP244 Lawn Mower Manual

The DeWalt DCMWSP244 is a 24V MAX* cordless push lawn mower featuring a 20-inch steel deck, dual-port rapid charger, two 12V MAX* 5.0Ah batteries, 5-position height adjustment (1.5-3.75 inches), brushless motor, single-lever folding handle, 2-in-1 mulching/bagging capability, and weather-resistant construction. Below are key sections for safety, features, assembly, operation, maintenance, and troubleshooting.

Features at a Glance

Key components: 20-inch steel cutting deck, Brushless motor, Folding handle with single-lever adjustment, Rear grass bag, Mulching plug, Dual-port rapid charger, Two 12V MAX* 5.0Ah batteries.

Assembly & Setup

Unpack and inspect all parts. Assemble on a flat, clear surface.

1. Attach the lower handle: Secure to deck using provided bolts and wrench.
2. Install the upper handle: Align with lower handle, insert pins, and secure knobs.
3. Attach grass bag: Hook bag frame onto rear deck hooks.
4. Install mulch plug: Insert into rear discharge opening for mulching mode.
5. Install batteries: Insert both 12V batteries into battery ports on deck.
6. Adjust cutting height: Set lever to desired position (test on a flat surface).

WARNING! Ensure mower is powered OFF and safety key is removed during assembly. Tighten all fasteners securely.

First-Time Operation

Before first use, fully charge both batteries.

1. Insert Safety Key: Push fully into slot on control panel.
2. Check battery level: Press battery indicator button on handle.
3. Select cutting mode: Install mulch plug or attach grass bag.
4. Adjust cutting height: Use single lever to set for your lawn condition.
5. Start mower: Hold safety lever on handle, then pull start switch.
6. Begin mowing: Walk at a steady pace, overlapping passes slightly.

CAUTION! Clear mowing area of stones, sticks, and debris. Do not mow wet grass.

Specifications

• Model: DCMWSP244
• Cutting Width: 20 inches
• Cutting Height Range: 1.5 - 3.75 inches (5 positions)
• Power System: 24V MAX* (Two 12V MAX* 5.0Ah batteries)
• Charger: Dual-port rapid charger (model DCB1102)
• Deck Material: 20-gauge steel
• Motor: Brushless
• Weight (without batteries): 55 lbs
• Grass Bag Capacity: 1.9 bushels
• Warranty: 3-year limited warranty

Controls and Adjustments

Main Controls: Safety Key, Start Switch, Safety Lever (bail), Battery Indicator, Height Adjustment Lever.

Handle Controls: Ergonomic grips, Safety lever (must be held to run), Battery indicator button, Folding release levers.

Height Adjustment: Single lever controls all four wheels simultaneously. Positions: 1 (1.5"), 2 (2.0"), 3 (2.5"), 4 (3.0"), 5 (3.75"). Battery Management: LED fuel gauge shows remaining charge (Green: 75-100%, Yellow: 25-75%, Red: 0-25%). Handle Folding: Pull release levers, fold handle down for compact storage.

Mowing Operations

For optimal performance and battery life.

1. Inspect area: Remove debris, toys, wires before mowing.
2. Check grass condition: Mow when grass is dry for best results.
3. Set appropriate height: Higher for first cut of season or uneven terrain.
4. Start mower: Insert key, hold safety lever, pull start switch.
5. Mowing pattern: Overlap each pass by 2-3 inches for even cut.
6. Slope mowing: Mow across slopes, not up and down.
7. Empty bag: When bag full indicator shows, stop and empty bag.

Tip: Mow frequently, removing no more than 1/3 of grass blade height per cut.

Mulching & Bagging

2-in-1 capability: mulch or bag clippings.

1. Mulching Mode: Install mulch plug completely in rear discharge opening. Mulching returns nutrients to lawn; ideal for regular mowing when grass is not too long.
2. Bagging Mode: Remove mulch plug, attach grass bag frame and bag. Use when grass is wet, very long, or when clippings collection is desired.
3. Switching Modes: Always turn mower OFF and remove safety key before changing modes.
4. Bag Full Indicator: Red flag raises when bag is approximately 80% full.

WARNING! Never operate without mulch plug OR grass bag properly installed. Keep hands away from discharge area.

Battery & Charging

24V MAX* system uses two 12V MAX* 5.0Ah batteries.

1. Charging: Use provided dual-port charger. Insert batteries into charger ports.
2. Charging Time: Approximately 90 minutes for fully depleted batteries.
3. Battery Care: Store batteries at room temperature. Charge before storage if not used for 30+ days.
4. Battery Indicator: Press button on handle to check charge level.
5. Run Time: Up to 60 minutes on fully charged batteries (varies with grass conditions).

CAUTION! Use only DeWalt 12V MAX* batteries and charger. Do not expose batteries to water or fire.

Maintenance & Storage

Regular maintenance ensures optimal performance and longevity.

1. After each use: Clean underside of deck (mower OFF, key removed).
2. Blade care: Check blade monthly for damage or dullness. Replace if bent or damaged.
3. Wheel maintenance: Check wheels for free movement; clean axle areas if debris accumulates.
4. Battery storage: Remove batteries, store in cool, dry place away from metal objects.
5. Off-season storage: Clean thoroughly, charge batteries fully, store in dry location.

CAUTION! Always remove safety key before performing any maintenance. Disconnect batteries when cleaning underside.

Safety Information

Read all instructions before operation. Keep bystanders and pets away.

• Wear appropriate clothing: long pants, sturdy shoes, eye protection.
• Never remove safety devices or guards.
• Do not mow on steep slopes (greater than 15 degrees).
• Never lift or carry mower while it is running.
• Keep hands and feet away from cutting area.
• Do not operate in rain or wet conditions.
• Remove safety key when not in use, especially around children.

DANGER! Blade continues to rotate after switch is released. Wait for complete stop before any adjustment or cleaning.

Troubleshooting

Reset: Remove safety key and batteries for 5 minutes to reset electronic system.

Service: 1-800-4-DeWalt (1-800-433-9258); www.dewalt.com